How much oil is in the UAZ Patriot engine? Lubricants and working fluids for uaz cars Refueling volumes uaz 3151

The entire line of UAZ Patriot cars has the same engine oil volume - these are strong, cheap and unpretentious cars.

UAZ "Bukhanka" is still used in all municipal spheres: both as a police car and as an ambulance. The secret of the popularity of this versatile vehicle lies in its simplicity of construction and cheap maintenance of the machine.

Liquids and filling volumes of UAZ Patriot engines

During the entire existence of the Ulyanovsk Automobile Plant, modernization car engine The Patriot was carried out three times. Initially, the UMP 417 model was developed - an engine with a volume of 2.45 liters with a capacity of 72 and 90 Horse power... It is such a unit that is installed in UAZ "Loaf" cars.

This car model has the following filling volumes and fluids:

• 56 liters - the main fuel tank and 30 - additional, A-76 gasoline is poured;
• 14.5 liters - cooling system, water, antifreeze, antifreeze are used as a coolant;
• 5.8 liters - Patriot engine volume, optimal lubricant of the M-8V1 brand (the factory initially filled in synthetic oil with a viscosity of 5W-30);
• 1 liter of grease requires the UAZ gearbox, recommended transmission fluid- 75W-90;
• 0.7 l - transfer case and 0.85 l - in each axle, TSP-15K or TAP-15V.

As you can see, the volumes of oils and liquids at "Loaf" are small, and the cost of the named brands is more than affordable. This explains the number of Ulyanovsk cars on the roads - among all domestic vehicles in UAZ old model you need to invest a minimum amount of finance.

At the same time, the engine of old UAZ vehicles is powerful enough to overcome any off-road conditions. Its cross-country ability can be compared with the Ural 4320.

New generation ZMZ engines The 409 differs significantly from the 417 model. The 409 model has a volume of 2.7 liters and 112 horsepower, respectively. Such a unit is installed on Patriot cars.

Loaf engine capacity

The size of the filling volume has also changed in relation to the "Loaf":

• Both fuel tank hold 36 liters of gasoline;
• The UAZ "Patriot" engine must be filled with up to 7 liters of oil volume;
• The gearbox requires 2.5 liters of gear oil;
• The oil capacity in the UAZ Patriot axles is different - 1.5 liters for the front and 1.4 liters for the rear;
• The dispenser holds only 0.8 liters.

The rest of the capacities of these two models of machines are equivalent, but the brands of lubricants and fluids for the Patriot differ from the Loaf. The new generation of vehicles requires more expensive maintenance. The cost of maintaining such a machine does not fit into the economy mode.

As for the third generation ICE of the Ulyanovsk Automobile Plant - UMP 421, it is a minimally modernized version of the UMP 417.

Maintenance of UAZ

In order for the machine to serve faithfully for many years, it is necessary to make timely Maintenance car. The above data of filling volumes should be known by heart by any zealous car owner.

In service centers quite often incompetent personnel work, and the cost of their services is unreasonably high. Therefore, the best solution would be to do the maintenance of the machine yourself. To do this, you need to know not only the filling volumes, but also the timing of the replacement of lubricants and fluids.

For example, you are the proud owner of Patriot with mechanical box gear. This vehicle requires service once a year or every 7000 km. To carry out maintenance on your own, you will need to replace the lubricants in the internal combustion engine, manual transmission, RK, axles, as well as oil and fuel filters, if necessary.

There is a lot of work to be done. First you need to replace the engine oil in the engine and change fuel filter... The replacement process takes place on a warmed-up machine - it's faster and more efficient.

The algorithm of actions is as follows:

1. The plug of the filler and drain holes is unscrewed. The hot oil is drained into a container.
2. Removable with a key oil filter.
3. The drain plug is lubricated with sealant and screwed into place.
4. A new filter is being installed.
5. The filler plug is screwed on.

It is important to note that when changing the type of oil after draining the mining, flushing liquid is poured. Otherwise, there is a risk of damage to the internal combustion engine.

In order to properly carry out maintenance, you need to know how much oil you need to fill in your car. The fact is that the volume of oil in the UAZ Patriot engine depends on the type of fuel. It will be necessary to pour 7 liters into a gasoline internal combustion engine, and 6.5 liters into a diesel engine.

After the internal combustion engine, we go to the manual transmission and the RK. Transmission grease is also drained from the heated machine. In principle, the algorithm of actions for changing the lubricant on the gearbox and transfer case is similar to that presented above.

Grease for manual transmission and RK is used the same. The required volume will be about 5 liters of liquid. It is advisable to choose a lubricant with a high viscosity, this will provide smooth operation car at low temperatures.

Oil change in axles occurs only after preliminary cleaning of the surfaces around the filler and drain holes. If this procedure is not followed, dust particles and metal chips will enter the system. Corks also need cleaning. The grease itself is filled with a syringe until the system overflows.

So, having carried out the listed work, you will spend about three hours of your time. This will save money on services service center, and most importantly, you will know that the service is performed with high quality and the transport is insured against unwanted breakdowns.

Let's answer the questions related to the filling of oil into various components and assemblies of the UAZ "Bukhanka" car.

How much oil is poured into the engine in the UAZ "Loaf"? For good engine performance, it is recommended to fill up to 7 liters of semi-synthetic engine oil. Viscosity grade - 10W-40.

When adding oil, check the oil level with the dipstick. An oil change is carried out every 10,000 kilometers or once a year.

Up to 1 liter of transmission is poured into the gearbox. synthetic oil with a viscosity grade of 75W-90 of GL-4 standard. Replacement is carried out every 45,000 kilometers of the vehicle's mileage.

The transfer case of the "Loaf" is filled with 0.7 liters of oil similar to the gearbox oil. Replace at 45,000 kilometers.

The gearboxes of the front and rear axles are filled with mineral hypoid oil (GL-5) with a viscosity of 80W-90, 0.85 liters each. Change oil every 45,000 kilometers.

Note that the frequency of replacement should be chosen based not only on the time and mileage indicated in the recommendations, but also on the condition of the car and its operating conditions.

buhanka-uaz.ru

Refueling volumes

Parameter	Automobile model
31512	3741	3962	2206	3303	3909	3153	33036	39094	39095
Fuel tanks
left (main)	39	56	56	56	56	56	39	56	56	56
right (additional)	39	30	30	30	56	30	39	56	30	56
Engine cooling system (including heater)	12,5- 12,7	13,2- 13,4	14,4- 14,6	14,4- 14,6	13,2- 13,4	14,4- 14,6	12,5- 12,7	13,2- 13,4	13,3- 13,4	13,2- 13,4
Engine lubrication system (including oil filter and oil cooler)	5,8
Transmission housing	1,0
Carter transfer case	0,7
Steering gear housing	0.25 (type screw-ball nut-sector - 0.5)
Power steering system	1,1
Axle carters (each)	0,85
Axle housings with final drives (each)	1,0
Carters final drives(each)	0,3
Shock absorbers (each)	0.320 (0.345; 0.295 - depending on the design)
System hydraulic drive brake system	0,52
Clutch hydraulic drive system	0,18
Windshield washer pump reservoir	2

uaz.service-manual.company

How Much Oil Is In a Box Uaz 469 ~ VESKO-TRANS.RU

Technical properties of the car UAZ 469

The still popular Russian SUV

The high cross-country vehicle UAZ 469, which appeared in our country at the beginning of the 70s of the twentieth century, for a long time remained the best Russian jeep. Due to its high reliability, maintainability in field conditions and a low price, this unpretentious workaholic still remains the standard for many four-wheel drive car.

Indeed, what other car can you fill with a muddy brownish slurry called A-72 gasoline, used engine oil and castor oil instead of brake water, and then drive our entire stately country from end to end without ditching the engine and the brake system. Renault Logan gearbox oil change. The technical properties of the UAZ 469 are unique, they make it possible to operate this jeep in such criteria that kill any other car.

The "goat" also has some drawbacks, namely, a tarpaulin awning instead of the usual roof and a weak stove, which make you click your teeth when traveling in the winter season. The answer to the question of how much oil is in the gearbox on a 16-valve VAZ-2112. How much oil to pour when changing? Oil change in the transfer case UAZ | motorists. But they are more than compensated for by the understanding of the fact that on the way you won't get stuck in a snowdrift and you won't freeze your limbs.

Main characteristics of the body and engine

Short description of the car UAZ 469 (469B):

• body - metal, open;
• type - frame convertible station wagon;
• number of seats - 7;
• number of doors - 5;
• length - 4025 mm;
• width - 1805 (1785) mm;
• height - 2050 (2015) mm;
• base - 2380 mm;
• clearance - 300 (220) mm;
• unloaded weight - 1600 (1540) kg;
• full load weight - 2400 (2280) kg;
• the volume of fuel tanks - 78 liters;
• the highest speed - 90 (120) km / h;
• ford depth - 0.7 m;
• the highest climb with a driver and 1 passenger - 57 °;
• the highest climb at full load - 31 °.

From the beginning of production, the civilian modification of the SUV was installed UMP engine 414.

The army models were equipped with the same power unit, but with pre-heater, because the motor has a different index - UMZ 41416.

• type - gasoline, atmospheric, 4-stroke;
• number of cylinders - 4;
• placement - in-line, vertical;
• the order of work - 1-2-4-3;
• cylinder diameter - 92 mm;
• piston stroke - 92 mm;
• the working volume of the motor is 2.5 liters;
• compression ratio - 6.7;
• power - 75 liters. with.;
• the highest torque - 167 Nm;
• average gas mileage on the highway - 10.75 liters per 100 km;
• highest consumption off-road gasoline - 17.25 liters per 100 kilometers;
• motor mass UMZ 414 s attachments and clutch, but without fluids - 163 kg;
• weight of UMP 41416 with awnings and clutch, but without liquids - 165 kg;
• the volume of cooling water (coolant) - 13 liters;
• coolant operating temperature - 80-90 ° С;
• the volume of engine oil in the cylinder block - 5.8 liters;
• normal oil pressure at Idling- 0.5-0.8 kg / cm³;
• normal oil pressure at speed is 2-5 kg ​​/ cm³.

Oil change in the box UAZ 469 79g.v

I decided to change the oil. Uaz 469, 31512, oil change in gearbox and razdatke uaz patriot; oil change in the gearbox and razdatka UAZ patriot. How much oil is in the box VAZ-2112 16 valves volume in the gearbox. And that's what I saw. How much oil is in the gearbox VAZ / Lada 2110. Changing the oil in the gearbox UAZ | motorists. New was filled in by TAD 17.

UAZ Axle oil change

Reporting video on Castrol 80w90 GL-5 oil Resource of oil in the UAZ Patriot Gearbox Castrol 80w90 GL-5 Why it's tight.

Under the hood of the 469 model

Features of transmission, chassis and control systems

The unique characteristics of the UAZ 469 are largely due to the successful design of the transmission. This system The car consists of a dry single-plate clutch, a gearbox (gearbox), a transfer case, a rear drive and front plug-in axles and wheel reducers for an army modification of an off-road vehicle.

Specifications Checkpoint:

• type - 4-speed, mechanical;
• synchronizers - in 3rd and 4th gears.

• 1st gear - 4.12;
• 2nd gear - 2.64;
• 3rd gear - 1.58;
• 4th gear - 1.00;
• reverse gear - 5.22;
• gearbox weight without lubrication - 33.5 kg;
• the volume of oil in the gearbox is 1 liter.

Technical characteristics of the transfer case: 2-speed, mechanical.

• direct transmission - 1.00;
• low gear - 1.94;
• power take-off - up to 40%;
• mass with hand brake, without lubrication - 37.4 kg;
• the volume of the oil to be poured is 0.7 l.

Cardan transmission- 2-shaft, open.

• front - 2-articulated, combined;
• front shaft weight - 6.9 kg;
• rear - 2-hinged, tubular;
• rear shaft weight - 8.25 kg.

• type - split, with gearboxes on all wheels;
• ratio - 5,38;
• the gear ratio of the main gear - 2.77;
• gear ratio of wheel reducers - 1.94;
• weight front axle- 140 kg;
• weight rear axle- 121.5 kg;
• the volume of oil poured into each bridge - 1 liter;
• the volume of oil poured into each wheel reducer is 0.3 liters.

• type - detachable;
• the gear ratio of the main gear - 5.13;
• front axle weight - 120 kg;
• rear axle weight - 100 kg;
• the volume of oil poured into each axle is 0.85 liters.

You can distinguish military bridges from collective farm bridges in the photo by the conical cap on the splined flange and the double main gear.

• suspension - rigid, spring;
• springs - 7-9-leaf, elliptical;
• shock absorbers - telescopic, double-acting;
• wheels - steel, stamped;
• tires - chamber;
• the recommended tire size is 215/90 R15.

• mechanism - worm-type;
• gear ratio - 20-21;
• the volume of the oil to be poured is 0.25 l.

• type - hydraulic, drum;
• parking brake - transmission;
• liquid volume - 0.52 l.

In general, the control systems of the UAZ 469 are reliable and durable.

vesko-trans.ru

Changing the oil in the uaz gearbox

Oil change SEQUENCE OF OPERATIONS Drain the oil from the gearbox immediately after the trip, until it has cooled down. We recommend combining this operation with changing the oil in the transfer case.

We install the car on a viewing ditch or lift.

Using a "12" hex wrench, unscrew the drain plug, substituting a container with a volume of at least 2 liters.

We drain the oil.

If the used oil is dark * or there are metal particles in it, we rinse the gearbox, for which we wrap the plug, cleaning its magnet from steel shavings. Then…

… With a 12 "hex wrench, unscrew the filler plug (for clarity, the front propeller shaft has been removed).

With an oil syringe, fill the box with about one liter of a mixture of transmission or engine oil (70-80%) with kerosene or diesel fuel(20-30%) and wrap the filler plug.

Having included the first gear, we start the engine for 2-3 minutes. We drain the flushing oil completely (drain duration is at least 5 minutes). We clean the drain plug again and wrap it up.

Fill the gearbox with 1 liter of fresh gear oil with an oil syringe (1.3 liters for five-speed box). We wrap the filler plug.

The design of absolutely every modern car requires the presence of power plant, tank, gearbox, and other units and various parts that have their own volumes. It is in these very volumes that diesel fuel is placed, and this is also brake fluid, of course, gasoline or antifreeze, but all liquids listed for each separate model are individual. We invite you to find out in detail about the refueling tanks on the UAZ Patriot, popular in our country, plus consider what they essentially are, in what quantity is required this model auto fill certain mechanisms.

All Patriot SUV refueling tanks

Everyone knows that filling tanks are units in which the presence of working fluid... By the way, the UAZ Patriot is equipped with 2 filling tanks at once, and this allows an SUV to fill up almost 2 times more fuel, almost up to 80 liters. Not all cars of this class can boast of the same design of the gas tank.

The filling volumes in the SUV we are considering are determined by the following details and mechanisms:

• Auto clutch system;
• Transmission;
• Lubrication system power unit;
• Carter handouts;
• Gasoline tanks;
• Power steering mechanism system;
• Glass washer pump reservoir;
• Engine cooling system 409;
• Brake system;
• Crankcases of 2 axles.

What fluids are needed for the Patriot to work

Domestic UAZ Patriot, which has a 409 engine, and a number of other cars that are similar in their mechanisms and design, without fail have the above refueling tanks, which are presented in the form of tanks made of plastic and located in various units. It is in such devices that there is a different working fluid. Check out the list of working fluids present in the UAZ Patriot:

• Transmission and engine oil refuel in the power unit, in the razdatka, as well as the checkpoint and bridges.
• Antifreeze or antifreeze is required for heating the passenger compartment and for cooling the engine;
• Depending on the design of the power plant, diesel fuel or gasoline.
• A liquid intended for glass washers, which is poured into the rear and windshield washer tanks.
• Brake fluid, it is poured into the clutch system, plus into the brake mechanism.

Refueling volumes of the Patriot SUV

• 5l. fluid is required in order to fill the windshield washer reservoir.
• Fuel tanks: the tank on the right and the tank on the right have the same volume, equal to 36 liters, this is according to the manufacturer's statement, however, as practice shows, a little more fuel can be poured into both tanks.
• Shock absorbers only need to pour 0.32L. liquids, but you should remember about the devices used in the suspension design.
• Engine lubrication is required in a volume of 7 liters, and for the model UAZ Patriot 31631 The volume of grease is 4.2L.
• The brake mechanism needs 0.6L. working fluid.
• For a radiator with horizontal tubes, 14 liters are required. liquid, and for heating the passenger compartment and the cooling system of the power unit - 12 liters.
• The clutch drive needs 0.18L. liquids.
• On manual transmission it will take 2.5l.
• For the steering gear, we measure - 0.25l.
• 0.8l is poured into the distributor crankcase.
• Power steering consumes 1.1l. working fluid, for the UAZ Patriot 31631 model you will need - 1.3l.
• As for the rear and front axles, their filling capacities require different amounts of fluid. The front axle requires 1.5 liters of oil, and the rear axle requires 1.4 liters. As practice shows, a little more than 1.4l is required to be poured into the rear axle crankcase. oil, so that all working elements inside are completely in lubricant.

We have listed all working fluids and their volumes without exception.

Each parameter is quite important, and all UAZ owners must necessarily have such data. For finer details, refer to the vehicle's operating manual.

Let's sum up

When you know exactly all the parameters, it will help to make accurate refueling or topping up during the replacement of a particular fluid. Any car system with a complete absence or low level of working fluid should be avoided, this harms the units and mechanisms of the machine, and reduces its service life. If you have any questions or want to leave a review, you can easily do this at the end of any material.

Engine.
Mod. 4178 (UAZ-31512) and 4179 (UAZ-3151), petrol, in-line, 4-cyl., 92x92 mm, 2.445 l, compression ratio 7.0, operating procedure 1-2-4-3, power 66 kW (90 hp) at 4000 rpm, torque 171.6 N * m (17.5 kgf * m) at 2200-2500 rpm; carburetor K-151V or K-126GU; air filter- inertial oil.

Transmission.
The clutch is single-disc, with peripheral springs, the shutdown drive is hydraulic. Transmission - 4-speed, with synchronizers in all forward gears; will transmit. numbers for synchronized gearbox: I-3.78; II 2.60; III 1.55; IV-1.0; ZX-4.12; will transmit. numbers for a gearbox with synchronizers in III and IV gears: I-4.124; II 2.641; III 1.58; IV-1.00; ZX-5.224. Transfer case - two-stage, gearbox numbers: highest - 1.00; the lowest - 1.94. Cardan drive - from two shafts. The main gear is bevel with spiral teeth; will transmit. numbers: on UAZ-31512 - 4.625, on UAZ-3151 - 2.77 and wheel reduction gears - 1.94 (total transmission number - 5.38).

Wheels and tires.
Wheels - with one-piece rim 6L-15. Tires - 8.40-15, air pressure in the front tires 1.7-1.9; rear - 1.9-2.1 kgf / cm. sq. , The number of wheels is 4 + 1.

Suspension.
Front and rear - on two semi-elliptical 7- or 9-leaf springs with telescopic shock absorbers.

Brakes.
Working brake system- with drum mechanisms (each block of the front wheels is driven from a separate cylinder, both blocks of the rear wheels - from one cylinder), a dual-circuit hydraulic drive (separate along the axes) and vacuum booster... Option-hydraulic drive without amplifier. The parking brake is a transmission brake with a drum brake and a mechanical drive.

Steering.
The steering gear is a globoidal worm with a two-ridge roller, transmit. number - 20.3.

Electrical equipment.
Voltage 12 V, ac. battery 6ST-60EM, generator G250-P2, voltage regulator PP132-A, starter 42.3708, breaker-distributor (for UAZ-3151) - P132, distributor sensor (for UAZ-31512) - 3302.3706, ignition coils: for UAZ-31512 - B116, for UAZ-31251 - B102-B, transistor switch (for UAZ-31512) - 1302.3734, spark plugs: for UAZ-31512 - All, for UAZ-3151 - CH302-B.

Filling volumes and recommended operating materials.
Fuel tank - 2x39 l, gasoline A-76;
cooling system (with heater) - 13L, water or antifreeze A-40, A-65;
engine lubrication system - 5.8 l, M-8B, M-6 / 10V (DV-ASZp-10V);
Gearbox housing - 1.0 l, TSp-15K (substitute for TAP-15V), at temperatures of minus 20-45 ° C, TSp-10 oil;
transfer case housing - 0.7 l,
steering box housing - 0.25 l,
drive axle housings - 2x1.0 l (UAZ-31512), - 2x0.85 l (for UAZ-3151);
wheel reduction housings - 2x0.3 l, circle of oil for the gearbox;
hydraulic brake system - 0.52 l;
clutch release hydraulic drive system - 0.18 l; brake fluid "Tom";
shock absorbers - 4x0.32 l, shock absorber fluid АЖ-12Т or spindle oil АУ;
windshield washer tank - 2L, water or NIISS-4 liquid mixed with water.

Unit weight(in kg).
Clutch engine - 165;
gearbox - 36,
transfer case with parking brake - 37,
cardan shafts - 15,
front axle - 120 (UAZ-31512) and 140 (UAZ-3151),
rear axle - 100 (UAZ-31512) and 122 (UAZ-3151),
frame - 112,
assembled body - 475,
wheel with tire - 39,
radiator - 10.

Each car in its design provides for the presence of a tank, engine, gearbox and many other parts and assemblies that have their own volumes. These volumes contain gasoline, diesel fuel, oil, brake fluid or antifreeze, but they are different for each model. Today we will pay attention filling tanks on the UAZ Patriot SUV and consider what they are, and in what quantity one or another vehicle mechanism should be filled.

What belongs to the components

Refueling tanks are units that contain working fluids. They periodically require replacement or refueling, as with a gas tank. By the way, the UAZ Patriot SUV is equipped with two refueling tanks, which makes it possible to increase the amount of fuel filled up to almost 80 liters. Few of the cars of this class can afford such a gas tank design.

The filling volumes include the following devices, mechanisms and parts:

• gas tanks;
• cooling system of the Patriot engine;
• Transmission;
• engine, or rather its lubrication system;
• cases of both axles;
• hydraulic power steering system;
• brake system;
• clutch system;
• glass washer pump reservoir;
• transfer case case.

UAZ Patriot, as well as others vehicles similar in design and having similar mechanisms, it necessarily has the filling volumes listed above, presented in the form of plastic tanks or located directly in the units themselves. It is in these devices that filling liquid for a particular mechanism. These fluids include the following:

• gasoline or diesel fuel, depending on the design of the engine itself;
• motor and transmission oil, which are refueled not only in the engine, but also in the gearbox, transfer case and axles;
• brake fluid poured into the brake mechanism and clutch system of an SUV;
• antifreeze or antifreeze, used for engine cooling and interior heating;
• windshield washer fluid, which is filled into the windscreen and rear window washer reservoir.

So, now we will consider the digital values ​​of all the above-mentioned devices, what volumes of working fluid they have and what they are.

Refueling volumes

For the Patriot, the filling volumes correspond to the following data:

• gas tanks: the left tank is designed for 36 liters, according to the manufacturer, the right one has the same volume and is 36 liters, although in fact it is known that you can fill a little more fuel into the gas tanks;
• the volume of the engine lubrication system is 7 liters, and for the UAZ Patriot 31631 models, the amount of lubricant is 4.2 liters;
  
• engine cooling and interior heating system - 12 liters, and for a radiator with horizontal tubes, the capacity is 14 liters;
• the manual transmission has a volume of 2.5 liters;
• the transfer case is about 0.8 liters;
• the front and rear axles of the rogue have filling volumes that differ in value from each other. So, for the front axle, 1.5 liters of oil is typical, and for the rear axle, 1.4 liters. But in fact, it is recommended to pour more than 1.4 liters of oil into the rear axle crankcase so that the working elements inside are completely absorbed by the lubricant;
• power steering gear - 1.1, and for the UAZ-31631 model - 1.3 liters;
• steering gear - 0.25;
• the clutch drive is 0.18L;
• brake mechanism - 0.6 l;
• shock absorbers - 0.32, but it all depends on the devices used in the suspension design;
• the windshield washer reservoir is 5 liters.

All these parameters are important and every owner of his car should have all the numbers. Otherwise, you can always refer to the operating instructions for the car and find out even the smallest details. If you have any questions or feedback, then you can always leave it at the end of each material.