Changing the oil in the automatic transmission is a mandatory procedure for long-term operation of the vehicle. Automatic transmission only works properly with good transmission oil. Such a liquid has various functions on the internal elements.
Why do you need oil in an automatic transmission?
Transmission fluid plays an important role in preventing internal parts from accelerating wear. The oil in the automatic transmission serves to create an oil film at the point of contact between the moving parts.
Main functions:
- Cooling. The fluid removes heat at the point of contact, which ensures reduced wear of the internal elements;
- Anti-corrosion properties. The parts do not have time to rust due to the coated oil film;
- Clutch. Increases adhesion between parts and ensures a smooth ride;
- Friction. Due to the correctly selected oil viscosity, friction between the parts is reduced, even at negative ambient temperatures.
A machine with bad oil behaves as follows:
- Difficult to switch (there is a delay);
- Shocks are felt when switching;
- There is noise in the box and vehicle cannot budge.
Why can oil leak?
It is not immediately possible to pinpoint the exact cause of the leak. A thorough analysis will be required. You need to open the hood, and then make your way to the bottom of the car. To get to the bottom of the vehicle, you will need a viewing hole or lift. The following are just examples of causes of oil leakage from the transmission system.
Reasons for oil leakage from automatic transmission Hyundai Grand Starex:
- Wear of oil seals;
- Wear on the surface of shafts that are in contact with other sealing elements;
- Backlash input shaft gear boxes;
- Damage to the layer between the hulls;
- Wear of the sealing element;
- The oil level dipstick is incorrectly installed;
- Drain plug or reverse sensor loose.
The main reason for the leak- wear of oil seals. To understand how to fix the leak, you need to figure out where such elements are installed.
They are installed in three locations:
- On the semi-axles.
- Input shaft.
- Gear selector rod.
To change the seals on the drive shaft, you will need:
When installing new seals, the following points are taken into account:
- The seals of the drive shafts are different for the left and right sides. They differ in the direction of the gene groove oil. The right side cuff has an arrow that indicates clockwise installation. On the left, the opposite is true.
- Before installing the oil seals, the working surface will need to be lubricated with fresh oil.
- The cuffs are installed with light hammer blows using specific supports.
If the oil in the gearbox is leaking as a result of wear on the selector shaft cuffs, the oil seal will need to be replaced:
- Remove the transmission drive joint retaining bolt and move it away from the rod.
- Remove the protective cover for the hinge.
- Remove the oil seal. To do this, use a screwdriver.
- Replace the new cuff. A mandrel is used. Lubricate the work surface with fresh oil before installing.
The sealing element on the drive shaft can only be removed if the transmission is disassembled. A similar procedure is combined with a clutch replacement. If you remove the bushing release bearing, you will need to open access to the oil seal.
If oily fluid is flowing from the joint of the transmission housings, it is best to dismantle and disassemble it. The crankcase joints are thoroughly cleaned of the sealing layer and degreased. Before assembly, it must be applied to threaded connections fresh oil.
The process of changing the oil in an automatic transmission on a Hyundai
Before starting an oil change due to the unsuitability of the fluid for further use or due to a breakdown of the automatic transmission, it is necessary to collect tools and materials for further work.
Required tools and materials:
- A set of hex keys (wrenches are also possible);
- Screwdriver and pliers;
- Metal brush;
- Container for waste liquid;
- Fresh oil;
- Sealing washer on the drain plug.
Step-by-step instructions for changing the oil in the automatic transmission Hyundai Grand Stareks:
- Warm up the engine. It is advisable to make a trip of 5-10 kilometers.
- Drain the oil. To do this, unscrew the crankcase guard. Get close to the transmission drain plug. Use a metal brush to clean the drain plug.
- Place the container under the drain hole. Unscrew carefully. Wait until the used oil is completely drained. About 15-20 minutes.
- Unscrew the pallet. Rinse it from metal shavings and dirt. Wipe dry.
- Install back.
- Fill in oil using a syringe. Pour in the required amount according to the level.
- Carry out a test drive for 10-15 kilometers using the shift lever in different positions. Return to the pit. Check the level. Top up if necessary.
The process of changing the oil in the automatic transmission in Grand Stareks has been completed.
Oil selection for Hyundai Grand Starex
Oil change in automatic transmission in Grand Stareks is carried out using the original fluid. At four and five stepped box it is recommended to fill in the following types of oils:
- DIA ATF SP III;
- Hyundai ATF SP III;
- Chevron ATF SP III.
The volume of oil in the automatic transmission is 10 liters. Replacement frequency - every 60,000 km.
* The price of all works - without the cost of oil!
Our showroom has a new set of equipment for a COMPLETE oil change in the gearbox.
Using an automatic transmission oil flushing unit and replacement ATF fluids all oil change operations in your car are carried out cleanly and in the shortest time.
In addition, with the standard oil change scheme, the inside of the gearbox remains up to 70% of the waste liquid!
This leads to disruption of oil movement, clogging of valves and accumulation of deposits, which, in turn, leads to accelerated wear of automatic transmission parts and, as a result, to breakdown and subsequent expensive repairs.
Now, with the SL45M installation, this problem won't get in your way.
Regular change of working fluids is the key to long-term and trouble-free operation of any vehicle. Oil change in automatic transmission Hyundai Stareks H1 is one of the specializations of our company. Let's talk about some of the nuances regarding the frequency of replacement and the rules for checking.
It is known that it is recommended to check the oil often - approximately every 5-10 thousand kilometers, which is articulated in the operating manual with advice from the manufacturer. According to existing regulations, complete replacement working fluid should be carried out at least every forty thousand kilometers and once every two years. Note that these norms cannot be applied to cars that drive on dusty roads or frequent traffic jams: in such cases, it is necessary to make a replacement every 20,000 kilometers. It is advisable to change the oil in the automatic transmission, not partially, but completely, through the flushing apparatus, thereby increasing the service life of the automatic transmission.
Grade
It is better to check the oil in the service, but you can do it yourself. In this case, ensure that the operating temperature reaches about seventy-five degrees (you can ride the car a little), and then set the vehicle on the site. Then move the selector to all possible positions and, staying at each of them for a couple of seconds, create a workload for subsequent verification. The final location is neutral.
You can estimate the amount of oil using a specialized dipstick. Be sure to use a clean tool, washing it after each lowering into the nozzle. Oil should be topped up if the oil level is below what is commonly referred to as "Hot". Consider that low level working fluid can damage the clutches. Other "symptoms" that indicate the need for replacement include: strange and bad smell burnt, uncharacteristic color, significant change in the degree of viscosity.
Hyundai starex- Korean minibus, one of the closest competitors Volkswagen Transporter... The car enjoys stable demand in a supported market, and finds a lot of fans - largely due to the ability to carry out repairs on its own. One of the most demanded procedures is checking and changing the oil in automatic box gear. According to official data, it is necessary to fill in liquid every 10 thousand kilometers, given the difficult climatic and road conditions in Russia. Let's take a closer look at how to properly change the oil in the Hyundai Starex automatic transmission.
What needs to be done to replace
- It is good to warm up the engine so that its temperature is 80 degrees. To do this, it is enough to make a short trip around the city, observing frequent stops and gas transfers.
- The car is installed on the observation deck, turns on parking brake... Move the automatic transmission selector to several positions. It is advisable to linger for 3-4 seconds in each mode in order to create a load on the box. Then move the selector to the "neutral" position (N)
- Use a dipstick to check the level of the remaining liquid. To do this, first take out the dipstick, clean it, then re-lower it into the hole. And finally, we take it out again and look at the exact level of the liquid. The optimum volume is when the oil print is between the Min and Max marks on the dipstick.
- Naturally, it is advisable to check not only the level, but also the quality of the remaining lubricant. If the liquid does not have a specific burning smell, and also has a light brown or light color, in this case, you can only add new oil. If the oil is black and stinks burnt, then a complete fluid change will be needed, along with draining the old grease
- A list of the following procedures is provided for those requiring a complete oil change. So, the car is driven onto the overpass, the engine is turned off. In the place under the bottom of the car there is a drain plug, it must be unscrewed, then observe the process of draining the spent liquid into a prepared container
- It is necessary to dismantle the pallet using a 10
- After removing the pallet, you will have access to oil filter, also take it out and change it to a new element
- Rinse the sump well from dirt deposits and metal shavings, then screw it on and put it back in place, not forgetting to put a new oil filter
- Most likely, before installing back in place of the pallet and drain plug, you will have to change their gaskets.
- The next step is to fill in new oil through the dipstick hole.
- To avoid complex flushing of automatic transmission in expensive dealership, you can do a double oil change. In this case, in continuation of point 10, it is necessary to start the engine and let it run for a few minutes. At this moment, all transmissions should be switched on in turn with a delay of 2-3 seconds in each mode. This will allow the oil to spread faster through all automatic transmission channels.
- Stop the engine and drain the oil into a container
- Refill the liquid through the control hole. Bring the liquid level to a certain rate indicated in the Min / Max form on the dipstick
- Start the engine, make a short trip, then measure the level again. If it is normal, then the process of changing the oil in the Hyundai Starex automatic transmission has been successfully completed.
How much oil to fill
The operating instructions indicate unequal volumes of oil to be poured into the Hyundai Starex gearbox. It all depends on the model year of manufacture and operating conditions. Usually the volume is in the range of 7-12 liters.
What type of oil for Hyundai Starex
There are several options transmission oils suitable for this model. Among them, we will highlight the best products - these are semisynthetics Hyundai ATF Matic-J, as well as cheaper oil Ravenol ATF Red-1 (synthetics).
servicing Kia and Hyundai
Why visit us:
Car service "Auto-Mig".
We do absolutely everything in terms of car repair Kia brands and Hyundai. Our employees have a wealth of experience and a large number of satisfied customers, all work is in line with the manufacturer's recommendations. In view of this, trusting us, you seem to be giving the repair to the manufacturer.
Our service provides high-quality repair services for your car, offering the most reasonable prices in terms of price / quality ratio, therefore, those who contact Us never return with the problem they came with, choosing from now on "Auto-Mig" constantly. We strive to provide the best possible repair safety for whatever we undertake.
Serving with us, you already in advance give the technical transport to serve much longer without breakdowns.
"Auto-Mig" is a guarantee of reliability and stability of your car in any conditions.
It is worth noting that modern Korean cars are not old copies of the Japanese, these are first-class cars of various classes, and are repaired in a special way, they already have their own history and can be repaired with high quality using only professionally thought-out technologies.
Our auto technical center provides the following services:
- full diagnostics of internal combustion engines, gearboxes and electronics;
- diagnostics of individual nodes, directions;
- repair of any complexity;
- air conditioner maintenance (troubleshooting, refueling);
- identification of incomprehensible breakdowns, due to which other service stations refuse and subsequent elimination.
We have the most advanced equipment to help you repair your vehicle better than anyone else, increasing the level of work done to the maximum.
We work on all Kia and Hyundai models, check the details by contacting any of our technical centers.
Repair of Kia in the AutoMig Car Service
(examples of work performed):
Repair Hyundai in the Auto-Mig Car Service
(examples of work performed):
Repair of commercial vehicles in our technical center:
Many Korean cars used by firms - these are small trucks Porter and Bongo. And for passenger transportation, usually Stareks H-1 and Carnival. For these fleets, we also offer our cordial approach and maximum attention.
- We work by bank transfer
- We conclude contracts
- We provide everything Required documents For accounting
Service of commercial vehicles
(examples of work performed):
Checking the car before buying
- We will help you to buy a car without "pitfalls". Inspection of the machine before purchasing will make sure it is in accordance with technical conditions claimed by the seller.
And just a little more about our technical center:
Our specialists will repair the engine and suspension of almost any degree of complexity. We use official electronic catalogs and follow the repair technology exactly. When conducting renovation works we use spare parts only from well-known manufacturers, which we purchase directly from importers, which ensures their low cost.
In the ‘AutoMig’ car service you can repair brake system Your Kia or Hyundai using quality materials and manufacturer's technology.
Come, we will be happy to help you!
On the benefits of replacing mineral oil in manual transmission
It should be noted that synthetic oil is often needed to create a slippery layer of mineral oil in those parts of the manual transmission where frequent contact of engaging parts with a high level of friction is formed. Even a negligible amount of non-lubricated gears with no protective layer synthetic oil, can cause significant mechanical incidents, therefore, changing the oil in the Hyundai H-1 (Grand Starex) manual transmission is a desirable and regular operation that cannot be forgotten. It should be noted that the maintenance at the car service, which is located in Varshavka, which is near the Yuzhnaya metro station, is a good prospect to service your car competently and cheaply.
Each driver is looking for an answer to the question - how often must the engine oil change in the automatic gearbox be carried out. Naturally, a regulation has been developed for any car - ten thousand kilometers, and most motorists follow it. But basically this number depends on the working conditions, and, of course, on the quality of the engine oil, nevertheless, changing the oil in the automatic box is a rather significant procedure for caring for a car, it is always worth remembering about it. If you intuitively worry about the performance of your beauty, then the problem - where to change the oil in an automatic gearbox in Moscow, may be urgent.
When to change the oil at the Hyundai Grand Stareks checkpoint, Prazhskaya metro station, Yuzhnaya metro station
Educated installers constantly say that engine oil should be changed regularly. At the same time * a complete oil change in the gearbox by the device, the price may slightly decrease. It is necessary to emphasize the points at which the oil change in the automatic box is somewhat faster:
- repeated trips over short distances - the motor cannot warm up in such a short time, which is why condensation appears with all the consequences. In severe frosts - this is very important, remember that changing the oil in the gearbox will make it possible not to be disappointed in your car;
- constant trips at the rate of a traffic jam - at this time, the operation of the cooling system deteriorates significantly, the oil heats up significantly, and, therefore, loses its quality more strongly. It must be remembered that the hardware change of the oil in the automatic transmission will increase the service life of the entire engine.
The cost of changing the oil in the gearbox Hyundai H-1 (Grand Starex)
It should be emphasized that during the daily operation of the car, engine oil loses all its good qualities over time, and at this moment changing the variator oil becomes really necessary for your car. This is expressed by the fact that the engine oil is contaminated with harmful waste products of diesel fuel combustion. Changing the oil in the manual transmission will provide an opportunity to extend the service life of the manual transmission, - come to the service station at the Prazhskaya metro stop, and you will be guaranteed perfect quality and perfect service.
What else you should know about changing the oil in manual transmission and automatic transmission Hyundai Grand Stareks
It is necessary to take into account the pace, conditions of movement and the proportionality of movement in the settlement or on the autobahn - all this affects the frequency of this procedure, like draining the variator oil. The highest and lowest temperatures (in cold and warm weather), driving on country roads, towing heavy loads greatly reduce the change interval for each synthetic oil.
Our advice is to change the oil and filters every 50,000 km, and it is worth remembering that regularly changing the oil in the gearbox will be key for its long and trouble-free operation.
